Bulk Aggregates for Patios in Stoutsville, OH

Ohio Rock Supply handles gravel and aggregate delivery in Stoutsville, OH for two kinds of buyers: contractors setting paver patios and flatwork, and homeowners rebuilding a drive or a garden bed. Both end up asking for the same base stone. Around here that is 304 limestone, the Ohio standard for a compacted base.

Fairfield County sits on clay loam and silty clay over gently rolling ground, so what you put under a patio matters as much as the pavers on top.

Ground and Conditions in Stoutsville

A paver patio fails at the bottom, not the top. When the base is too thin, the bedding layer takes the load instead, and the surface shifts, dips and holds water within a season or two.

The local ground makes that worse. Glacial till of clay loam to silty clay drains slowly, so water ponds in flat swales and low spots after spring rain and snowmelt. Wet clay also will not compact well, which is why base and paver work waits until the ground thaws and the flats dry out.

Cold winters add repeated freeze-thaw, which heaves wet clay under drives and patios and lifts shallow posts and pads. Frost depth is 32 inches in Columbus and Dayton, set by each local building department. A thick, well-compacted 304 limestone base is what keeps a patio flat through that cycle.

Materials for Stoutsville Projects

Bedding is where a patio is won or lost. Under pavers you want a base that locks up hard, then a thin leveling course that lets you set each unit without rocking. Start with 304 Aggregate Base. It compacts into a firm, load-spreading layer.

Over that base, Screenings (limestone screenings or stone dust) give you the fine, 1/4 inch and down material that beds pavers and patio slabs. For a gravel surface instead of pavers, cap the base with 411 Stone, also called 411 limestone, which packs tight over 304.

Drainage around the patio edge matters just as much. #57 Limestone is the clean stone Ohio suppliers stock most widely, and it works in French drains and behind retaining walls. Drain Rock handles downspout runs, foundation drains and drainage behind walls. For finer work, #8 Crushed Stone suits pipe bedding and paver joints.

Two more that come up on nearly every flatwork job:

• Washed Sand for leveling and bedding under slabs.
• Mason Sand for brick and block work and paver joints.

Delivery to Stoutsville and the Surrounding Area

Order online, pick your material, then choose the quantity by the ton or by the yard. If you are unsure which unit fits your job, the calculator sizes the load for you, so you are not guessing at a number.

Bulk delivery to a site in Stoutsville arrives by dump truck and is tipped where you want it. Pick a delivery date at checkout and have the drop spot clear before the truck arrives. Ohio Rock Supply also delivers to Lancaster, Pickerington, Baltimore, Lithopolis and Bremen in Fairfield County.

Questions About Gravel and Patio Base in Stoutsville

What gravel is best for a driveway in Stoutsville?

For a new drive, start with 304 limestone as the base, then top it with 411 limestone for a surface that packs tight. If the drive only needs a fresh surface over an existing compacted base, 411 limestone or Driveway Gravel will do it. Where drainage is the problem, a clean stone like #57 limestone keeps water moving instead of trapping it.

How much material will my project need?

Use the calculator to size the load. Enter your project area and the depth you want, and it converts that into tons or yards. The result tells you how much 304 limestone or bedding sand to order, and you can round up if you would rather have a little left over than come up short mid-job.

Size the Load, Then Set the Date

Base, bedding and drainage all come down to quantity and timing. Run your patio or driveway dimensions through the calculator to get tons or yards, then choose a delivery date at checkout. Ohio Rock Supply brings 304 limestone, screenings, 411 limestone and clean stone to your site in Stoutsville, ready for your crew.