Bulk Aggregates for Patios in Morrow, OH

Ohio Rock Supply handles gravel and aggregate delivery in Morrow, OH for two kinds of buyers. Contractors order 304 limestone by the load for base work, and homeowners order a few tons for a patio or a driveway refresh. Both get the same material, sized to the job and dropped where the work is happening.

Morrow sits on clay loam and silty clay till that drains slowly, so a patio here needs stone that packs and sheds water rather than holding it.

Ground and Conditions in Morrow

A patio base that was built too thin shows itself fast in this ground. The edges settle, the pavers rock, and water sits in the low spots after spring rain. Clay till under the base holds that moisture instead of passing it down.

The fix is a thicker compacted base and a drainage layer that carries water away. On flat ground, that means building up rather than cutting in. Graded soil that stays bare over winter also washes and slumps, so cover it once the base is set.

Timing matters as much as depth. Base, driveway and paver work runs from thaw through late fall. Frozen or saturated clay will not compact, and a patio base built on it will move.

Cold winters bring repeated freeze-thaw, which heaves wet clay under drives and patios and lifts shallow posts and pads. Frost depth runs 32 inches in Columbus and Dayton, set by each local building department.

Materials for Morrow Projects

For patios and flatwork, bedding is the decision that matters most. The bedding layer levels the pavers and spreads load down into the base, so it has to pack tight without shifting.

Below the bedding, 304 Aggregate Base, known locally as 304 limestone or #304 stone, is the standard Ohio base stone. Build the base from 304, then bed the pavers above it.

For the bedding layer itself, Screenings, also called limestone screenings or stone dust, run from about 1/4 inch down to dust. That mix compacts firm, which is what a paver bed needs.

Where the patio meets a wall or a downspout, #57 Limestone handles drainage. It is clean stone, so water moves through it instead of pooling against the house. #8 Crushed Stone works for tighter drainage runs and pipe bedding.

Sand has its place under flatwork too. Washed Sand, or concrete sand, levels and beds under slabs, and Mason Sand fills paver joints.

Delivery to Morrow and the Surrounding Area

You order online and choose a quantity by the ton or by the yard, whichever you measured in. If you are not sure how much a patio base or a bedding layer takes, the calculator sizes the load for you.

Pick your delivery date at checkout, and a dump truck brings the material to your site in Morrow. Warren County coverage also reaches Mason, Lebanon, Springboro, Franklin and South Lebanon.

Have the drop spot clear and reachable before the truck arrives. Bulk stone is dumped, not placed, so the pile lands where it can be worked from.

Order Your Patio Material for Morrow

Work out the quantity with the calculator, pick the material that fits your base and bedding, and choose a delivery date that lines up with your schedule. Ohio Rock Supply delivers bulk aggregate across Morrow and Warren County. Place your order online when you are ready.